Carrier XRV Especificaciones Pagina 179
- Pagina / 190
- Tabla de contenidos
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
Catalog No. 04-53190015-01 Printed in U.S.A. Form 19XRV-5SS Pg CL-1 312 12-11 Replaces: 19XRV-2SS
INITIAL START-UP CHECKLIST
FOR 19XRV HERMETIC CENTRIFUGAL LIQUID CHILLER
(Remove and use for job file.)
MACHINE INFORMATION:
DESIGN CONDITIONS:
REFRIGERANT: Type: Charge
START-UP TO BE PERFORMED IN ACCORDANCE WITH APPROPRIATE MACHINE START-UP INSTRUCTIONS
JOB DATA REQUIRED:
1. Machine Installation Instructions Yes No
2. Machine Assembly, Wiring and Piping Diagrams Yes No
3. Starting Equipment Details and Wiring Diagrams Yes No
4. Applicable Design Data (see above) Yes No
5. Diagrams and Instructions for Special Controls Yes No
INITIAL MACHINE PRESSURE:
RECORD PRESSURE DROPS: Cooler Condenser
CHARGE REFRIGERANT: Initial Charge Final Charge After Trim
NAME JOB NO.
ADDRESS MODEL
CITY STATE ZIP S/N
TONS
(kW)
BRINE
FLOW
RATE
TEMPERATURE
IN
TEMPERATURE
OUT
PRESSURE
DROP
PASS
SUCTION
TEMPERATURE
CONDENSER
TEMPERATURE
COOLER ******
CONDENSER ******
CHILLER LINE SIDE: Volts FLA OLTA
OIL PUMP: Volts RLA OLTA
CARRIER OBLIGATIONS: Assemble... . . . . . . . . . . . . . . . . Ye s No
Leak Test . . . . . . . . . . . . . . . . . . . Ye s No
Dehydrate . . . . . . . . . . . . . . . . . . Ye s No
Charging . . . . . . . . . . . . . . . . . . . Ye s No
Operating Instructions Hrs.
YES NO
Was Machine Tight?
If Not, Were Leaks Corrected?
Was Machine Dehydrated After Repairs?
CHECK OIL LEVEL AND RECORD: ADD OIL: Ye s No
Amount:
1/2 Top sight glass
1/2 Bottom sight glass
3/4
1/4
3/4
1/4
a23-190
- EVERGREEN 1
- 50/60 Hz 1
- CONTENTS 2
- CONTENTS (cont) 3
- INTRODUCTION 4
- CHILLER FAMILIARIZATION 5
- (Fig. 1 and 2) 5
- REAR VIEW 7
- FRONT VIEW 7
- REFRIGERATION CYCLE 8
- MOTOR AND LUBRICATING OIL 8
- COOLING CYCLE 8
- STARTING EQUIPMENT 10
- OPTIONAL 11
- 442A AND 608A VFDs 12
- 900A AND 1200A VFDs 12
- CONTROLS 15
- Definitions 15
- Fig. 10 — Control Panel 17
- Fig. 11 — Power Panel 17
- 55.1 44.1 40.7 20
- 85.0 95.0 98.1 20
- 21.8 132.9 93 20
- Table 4 — ICVC Display Data 27
- 0.1-3.0 SP_HIGH 28
- 0.1-3.0 SP_HIGH 1.0 37
- PIC III System Functions 40
- ECW-10 sec 41
- Error, Gain = 1 41
- Error, Gain = 3 41
- START-UP/SHUTDOWN/ 57
- RECYCLE SEQUENCE (Fig. 27) 57
- Local Start-Up — 57
- Shaft Packing — 60
- LIQUID LINE 63
- Temperature (F) 64
- Temperature (C) 64
- • Surge/ HGBP Deadband = 1 69
- ΔT increase 70
- Delta Tsat 71
- ALARM CONTROL 72
- ALARM ROUTING 72
- LEGEND TO TABLES 16A-16J 91
- E. START-UP IN PROGRESS 92
- F. NORMAL RUN 93
- G. NORMAL RUN WITH OVERRIDES 93
- H. OUT-OF-RANGE SENSOR 94
- J. CHILLER ALERTS 99
- J. CHILLER ALERTS (cont) 100
- Control Modules 107
- Notes on Module Operation 107
- RECTIFIER LED 109
- INVERTER LED 109
- Table 30 — Motor Voltage Code 129
- COMPRESSOR, TRANSMISSION AREA 130
- LOW SPEED SHAFT THRUST DISK 131
- LEGEND FOR FIG. 53-58 133
- SEE NOTE 134
- HOT GAS BYPASS 135
- HOT GAS BYPASS OPTION FOR 136
- NOTE: MOTOR OVERLOAD IS 143
- FACTORY PRE-SET 143
- DO NOT ADJUST 143
- COMBINED I/O 144
- TB1 − LF2 146
- TB3 − LF2 146
- VFD (cont) 147
- LEGEND FOR FIG. 60 148
- NOTES FOR FIG. 60 149
- NOTE 3.6 150
- LEGEND FOR FIG. 61 152
- NOTES FOR FIG. 61 153
- 19XRV CHILLERS 154
- STATUS VPF_STAT 163
- APPENDIX B — LEAD/LAG WIRING 165
- 19XRV Weekly Maintenance Log 168
- 19XRV Maintenance Log 169
- 19XRV Seasonal Shutdown Log 170
- 10's 171
- 1's 171
- — The LEDs indicate if the 175
- Table G — Network Points List 176
- INITIAL START-UP CHECKLIST 179
- No 180
- *If yes, determine cause 180
- DRAWINGS) 180
- 0.1 to 3.0 184
- CCN LOCAL RESET MENU 190
Relacionado con productos y manuales para No Carrier XRV
No Carrier 19FA Instrucciones de operaciones
(42 paginas)
(42 paginas)
No Carrier 69NT40-511-1 Manual de usuario
(36 paginas)
(36 paginas)
No Carrier Supra 650 Manual de servicio
(92 paginas)
(92 paginas)
No Carrier 60 El manual del propietario
(29 paginas)
(29 paginas)
No Carrier 48TCA04---A12 Manual de usuario
(78 paginas)
(78 paginas)
No Carrier JWL-1221VS Instrucciones de operaciones
(32 paginas)
(32 paginas)
No Carrier 69NT40-511-1 Manual de servicio
(138 paginas)
(138 paginas)
No Carrier 4DF-13 Manual de usuario
(4 paginas)
(4 paginas)
No Carrier Supra 650 Instrucciones de operaciones
(24 paginas)
(24 paginas)
No Carrier 69NT40-511-1 Manual de servicio
(123 paginas)
(123 paginas)
No Carrier 751 Especificaciones
(8 paginas)
(8 paginas)
No Carrier HRVCCSVU Manual de usuario
(2 paginas)
(2 paginas)
No Carrier HFC-134a Manual de usuario
(32 paginas)
(32 paginas)
No Carrier AQUASNAP MPW015-045 Especificaciones
(80 paginas)
(80 paginas)
No Carrier 060 Manual de instalación
(32 paginas)
(32 paginas)
No Carrier PC211 Especificaciones
(116 paginas)
(116 paginas)
No Carrier 23XL Manual de usuario
(48 paginas)
(48 paginas)
No Carrier 8DF-13 Guía de usuario
(75 paginas)
(75 paginas)
No Carrier 10DF-13 Manual de usuario
(16 paginas)
(16 paginas)
No Carrier Miracool El manual del propietario
(14 paginas)
(14 paginas)
© 2020, manymanuals.es. Todos los derechos reservados | 0.110 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales