Carrier XRV Especificaciones Pagina 3
- Pagina / 190
- Tabla de contenidos
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
3
CONTENTS (cont)
Page
Standing Vacuum Test . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Chiller Dehydration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Inspect Water Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Check Optional Pumpout Compressor
Water Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Check Relief Valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Identify the VFD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
• IDENTIFYING THE DRIVE BY PART NUMBER
Input Power Wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
Checking the Installation . . . . . . . . . . . . . . . . . . . . . . . . 66
Inspect Wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Ground Fault Troubleshooting . . . . . . . . . . . . . . . . . . 67
Carrier Comfort Network
®
Interface . . . . . . . . . . . . . 67
Power Up the Controls and
Check the Oil Heater . . . . . . . . . . . . . . . . . . . . . . . . . . 67
• SOFTWARE VERSION
Software Configuration . . . . . . . . . . . . . . . . . . . . . . . . . 68
Input the Design Set Points . . . . . . . . . . . . . . . . . . . . . 68
Input the Local Occupied Schedule
(OCCPC01S) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Input Service Configurations. . . . . . . . . . . . . . . . . . . . 68
• PASSWORD
• INPUT TIME AND DATE
• CHANGE ICVC CONFIGURATION
IF NECESSARY
• TO CHANGE THE PASSWORD
• TO CHANGE THE ICVC DISPLAY FROM
ENGLISH TO METRIC UNITS
• CHANGE LANGUAGE
• MODIFY CONTROLLER IDENTIFICATION
IF NECESSARY
• INPUT EQUIPMENT SERVICE PARAMETERS
IF NECESSARY
• VERIFY VFD CONFIGURATION AND CHANGE
PARAMETERS IF NECESSARY
• VFD CHILLER FIELD SET UP AND VERIFICATION
• HAND CALCULATE VARIABLE PRIMARY FLOW
(VPF) SURGE PREVENTION CONFIGURATIONS
• CONFIGURE DIFFUSER CONTROL IF
NECESSARY
• MODIFY EQUIPMENT CONFIGURATION
IF NECESSARY
Perform a Control Test . . . . . . . . . . . . . . . . . . . . . . . . . . 72
• PRESSURE TRANSDUCER CALIBRATION
Check Optional Pumpout System
Controls and Compressor. . . . . . . . . . . . . . . . . . . . . 74
High Altitude Locations . . . . . . . . . . . . . . . . . . . . . . . . . 74
Charge Refrigerant Into Chiller . . . . . . . . . . . . . . . . . . 74
• CHILLER EQUALIZATION WITHOUT A
PUMPOUT UNIT
• CHILLER EQUALIZATION WITH
PUMPOUT UNIT
• TRIMMING REFRIGERANT CHARGE
INITIAL START-UP. . . . . . . . . . . . . . . . . . . . . . . . . . . . .77,78
Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Check Motor Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Check Oil Pressure and Compressor Stop . . . . . . 78
To Prevent Accidental Start-Up. . . . . . . . . . . . . . . . . . 78
Check Chiller Operating Condition . . . . . . . . . . . . . . 78
Instruct the Customer Operator . . . . . . . . . . . . . . . . . 78
• COOLER-CONDENSER
• OPTIONAL PUMPOUT STORAGE TANK AND
PUMPOUT SYSTEM
• MOTOR COMPRESSOR ASSEMBLY
• MOTOR COMPRESSOR LUBRICATION SYSTEM
• CONTROL SYSTEM
• AUXILIARY EQUIPMENT
• DESCRIBE CHILLER CYCLES
Page
• REVIEW MAINTENANCE
• SAFETY DEVICES AND PROCEDURES
• CHECK OPERATOR KNOWLEDGE
• REVIEW THE START-UP, OPERATION, AND
MAINTENANCE MANUAL
OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . 78-80
Operator Duties . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Prepare the Chiller for Start-Up . . . . . . . . . . . . . . . . . 78
To Start the Chiller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Check the Running System . . . . . . . . . . . . . . . . . . . . . 78
To Stop the Chiller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
After Limited Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . 79
Preparation for Extended Shutdown . . . . . . . . . . . . 79
After Extended Shutdown . . . . . . . . . . . . . . . . . . . . . . . 79
Cold Weather Operation. . . . . . . . . . . . . . . . . . . . . . . . . 79
Manual Guide Vane Operation. . . . . . . . . . . . . . . . . . . 79
Refrigeration Log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
PUMPOUT AND REFRIGERANT TRANSFER
PROCEDURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81-84
Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Operating the Optional Pumpout Unit . . . . . . . . . . . 81
• POSITIVE PRESSURE CHILLERS WITH
STORAGE TANKS
• CHILLERS WITH ISOLATION VALVES
• DISTILLING THE REFRIGERANT
GENERAL MAINTENANCE . . . . . . . . . . . . . . . . . . . .84,85
Refrigerant Properties . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Adding Refrigerant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Removing Refrigerant. . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Adjusting the Refrigerant Charge . . . . . . . . . . . . . . . 84
Refrigerant Leak Testing . . . . . . . . . . . . . . . . . . . . . . . . 84
Leak Rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Test After Service, Repair, or Major Leak . . . . . . . . 84
• TESTING WITH REFRIGERANT TRACER
• TESTING WITHOUT REFRIGERANT TRACER
• TO PRESSURIZE WITH DRY NITROGEN
Repair the Leak, Retest, and Apply
Standing Vacuum Test . . . . . . . . . . . . . . . . . . . . . . . . 85
Checking Guide Vane Linkage . . . . . . . . . . . . . . . . . . 85
Trim Refrigerant Charge. . . . . . . . . . . . . . . . . . . . . . . . . 85
WEEKLY MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . 85
Check the Lubrication System . . . . . . . . . . . . . . . . . . 85
SCHEDULED MAINTENANCE . . . . . . . . . . . . . . . . 86-88
Service Ontime. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Inspect the Control Panel . . . . . . . . . . . . . . . . . . . . . . . 86
Check Safety and Operating Controls
Monthly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Changing Oil Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Oil Specification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Oil Changes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
• TO CHANGE THE OIL
Refrigerant Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Oil Reclaim Filter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
VFD Refrigerant Strainer . . . . . . . . . . . . . . . . . . . . . . . . 87
Inspect Refrigerant Float System . . . . . . . . . . . . . . . 87
Inspect Relief Valves and Piping . . . . . . . . . . . . . . . . 87
Compressor Bearing and Gear
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Inspect the Heat Exchanger Tubes
and Flow Devices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
• COOLER AND OPTIONAL FLOW DEVICES
• CONDENSER AND OPTIONAL FLOW DEVICES
Water Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Water Treatment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Inspect the VFD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Recalibrate Pressure Transducers . . . . . . . . . . . . . . 88
- EVERGREEN 1
- 50/60 Hz 1
- CONTENTS 2
- CONTENTS (cont) 3
- INTRODUCTION 4
- CHILLER FAMILIARIZATION 5
- (Fig. 1 and 2) 5
- REAR VIEW 7
- FRONT VIEW 7
- REFRIGERATION CYCLE 8
- MOTOR AND LUBRICATING OIL 8
- COOLING CYCLE 8
- STARTING EQUIPMENT 10
- OPTIONAL 11
- 442A AND 608A VFDs 12
- 900A AND 1200A VFDs 12
- CONTROLS 15
- Definitions 15
- Fig. 10 — Control Panel 17
- Fig. 11 — Power Panel 17
- 55.1 44.1 40.7 20
- 85.0 95.0 98.1 20
- 21.8 132.9 93 20
- Table 4 — ICVC Display Data 27
- 0.1-3.0 SP_HIGH 28
- 0.1-3.0 SP_HIGH 1.0 37
- PIC III System Functions 40
- ECW-10 sec 41
- Error, Gain = 1 41
- Error, Gain = 3 41
- START-UP/SHUTDOWN/ 57
- RECYCLE SEQUENCE (Fig. 27) 57
- Local Start-Up — 57
- Shaft Packing — 60
- LIQUID LINE 63
- Temperature (F) 64
- Temperature (C) 64
- • Surge/ HGBP Deadband = 1 69
- ΔT increase 70
- Delta Tsat 71
- ALARM CONTROL 72
- ALARM ROUTING 72
- LEGEND TO TABLES 16A-16J 91
- E. START-UP IN PROGRESS 92
- F. NORMAL RUN 93
- G. NORMAL RUN WITH OVERRIDES 93
- H. OUT-OF-RANGE SENSOR 94
- J. CHILLER ALERTS 99
- J. CHILLER ALERTS (cont) 100
- Control Modules 107
- Notes on Module Operation 107
- RECTIFIER LED 109
- INVERTER LED 109
- Table 30 — Motor Voltage Code 129
- COMPRESSOR, TRANSMISSION AREA 130
- LOW SPEED SHAFT THRUST DISK 131
- LEGEND FOR FIG. 53-58 133
- SEE NOTE 134
- HOT GAS BYPASS 135
- HOT GAS BYPASS OPTION FOR 136
- NOTE: MOTOR OVERLOAD IS 143
- FACTORY PRE-SET 143
- DO NOT ADJUST 143
- COMBINED I/O 144
- TB1 − LF2 146
- TB3 − LF2 146
- VFD (cont) 147
- LEGEND FOR FIG. 60 148
- NOTES FOR FIG. 60 149
- NOTE 3.6 150
- LEGEND FOR FIG. 61 152
- NOTES FOR FIG. 61 153
- 19XRV CHILLERS 154
- STATUS VPF_STAT 163
- APPENDIX B — LEAD/LAG WIRING 165
- 19XRV Weekly Maintenance Log 168
- 19XRV Maintenance Log 169
- 19XRV Seasonal Shutdown Log 170
- 10's 171
- 1's 171
- — The LEDs indicate if the 175
- Table G — Network Points List 176
- INITIAL START-UP CHECKLIST 179
- No 180
- *If yes, determine cause 180
- DRAWINGS) 180
- 0.1 to 3.0 184
- CCN LOCAL RESET MENU 190
Relacionado con productos y manuales para No Carrier XRV
No Carrier 19FA Instrucciones de operaciones
(42 paginas)
(42 paginas)
No Carrier 69NT40-511-1 Manual de usuario
(36 paginas)
(36 paginas)
No Carrier Supra 650 Manual de servicio
(92 paginas)
(92 paginas)
No Carrier 60 El manual del propietario
(29 paginas)
(29 paginas)
No Carrier 48TCA04---A12 Manual de usuario
(78 paginas)
(78 paginas)
No Carrier JWL-1221VS Instrucciones de operaciones
(32 paginas)
(32 paginas)
No Carrier 69NT40-511-1 Manual de servicio
(138 paginas)
(138 paginas)
No Carrier 4DF-13 Manual de usuario
(4 paginas)
(4 paginas)
No Carrier Supra 650 Instrucciones de operaciones
(24 paginas)
(24 paginas)
No Carrier 69NT40-511-1 Manual de servicio
(123 paginas)
(123 paginas)
No Carrier 751 Especificaciones
(8 paginas)
(8 paginas)
No Carrier HRVCCSVU Manual de usuario
(2 paginas)
(2 paginas)
No Carrier HFC-134a Manual de usuario
(32 paginas)
(32 paginas)
No Carrier AQUASNAP MPW015-045 Especificaciones
(80 paginas)
(80 paginas)
No Carrier 060 Manual de instalación
(32 paginas)
(32 paginas)
No Carrier PC211 Especificaciones
(116 paginas)
(116 paginas)
No Carrier 23XL Manual de usuario
(48 paginas)
(48 paginas)
No Carrier 8DF-13 Guía de usuario
(75 paginas)
(75 paginas)
No Carrier 10DF-13 Manual de usuario
(16 paginas)
(16 paginas)
No Carrier Miracool El manual del propietario
(14 paginas)
(14 paginas)
© 2020, manymanuals.es. Todos los derechos reservados | 0.071 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales